DIRECTIONS FOR PUMPING. ( Copyrighted; Reprint Forbidden. )

Previous

One gallon of pumping brine is sufficient for pumping one tierce, or 285 lbs. of meat. Make the pumping brine as follows:

½ lb. of Freeze-Em-Pickle.
1 lb of Pure Granulated Sugar.
2 lbs. of Salt.
1 gal. of Water.

The sugar used must be Pure Granulated Sugar; yellow or brown sugar must not be used. When adulterated sugar is used, the brine becomes thick and would spoil the meat in two weeks. Stir the above thoroughly before using. As this will make a thick brine which is more than saturated, it will precipitate when left standing, therefore, when mixed in large quantities, it should be stirred occasionally. Meats should never be pumped with anything but a solution that is thoroughly saturated.

HAMS

SHOULDERS

Pump the Hams or Shoulders just before they are packed, and if it is desired to rush the cure, pump them every time that the meat is overhauled. The pumping solution must be cold when pumped into the meat. Ordinarily, three insertions of the needle in the Hams are sufficient; once at the shank to the hock joint as shown at A, once to the thigh and along the bone, Fig. B., and once from the butt end to the joint under the hip bone and into the fleshy part, Fig. C. Solid lines show needle up to point of insertion and dotted line shows direction taken by needle after insertion. In a very heavy Ham as many as six insertions should be made, and the same with very heavy Shoulders. Three insertions of the needle into a medium size Shoulder are sufficient; one at Fig. D, one to the shoulder joint at Fig. E, and one under the blade from the end, or diagonally from the back of the shoulder toward the end at Fig. F. More insertions may be made without injury to the meat, but the above are all that are required for good results. One cubic inch of solution is enough for each insertion, and after withdrawing the needle, the hole must be squeezed shut with the thumb to prevent the solution from oozing out. Stir the solution well before starting to pump. The Pumper must be careful not to pump air into the meat. Never allow the Pickle to go below the end of sucker of pump.

                                                                                                                                                                                                                                                                                                           

Clyx.com


Top of Page
Top of Page